IPA 2 mixing station 

IPA 2 mixing station 

The IPA mixing station allows a precise mixing of pre-defined formulations. It is the optimum solution for typical production processes in the most varied of industries. The system's modularity permits diverse configurations to be implemented in a safe laboratory environment.

Training content:

  • Setup, wiring and start-up of a process plant

  • Selection, application and connection of various sensors

  • Measurement of electrical and process variables such as filling level and flow rate

  • Formulation control

  • Use and connection of measurement transducers

  • Setup and operation of control loops

  • Analysis of controlled systems and control loops

  • Operation of continuous and discontinuous controllers

  • Parameterization and optimization of P-, PI- and PID controllers

  • Design of open-loop and closed-loop control programs

  • Process handling and monitoring

  • Inspection, maintenance and repair

  • Networking of process plants

 

Basic equipment set, consisting of: 
1
IPA mixing station
IPA mixing station LM9551
1
Mechatronics aluminium profile carriage without table-top frame
Mechatronics aluminium profile carriage without table-top frame ST7200-3R
Accessories:
1
25-pin serial interface cable, Sub-D plug/socket
25-pin serial interface cable, Sub-D plug/socket LM9061
2
Safety measurement cable (4mm), 100cm/40", blue
Safety measurement cable (4mm), 100cm/40", blue SO5126-9A
2
Safety measurement cable (4mm), 100cm/40", red
Safety measurement cable (4mm), 100cm/40", red SO5126-8U
2
Safety measurement cable (4mm), 150cm, yellow
Safety measurement cable (4mm), 150cm, yellow SO5126-9H
1
Safety measurement cable (4mm), 150cm, green
Safety measurement cable (4mm), 150cm, green SO5126-9P
1
Safety measurement cable (4mm), 150cm, blue
Safety measurement cable (4mm), 150cm, blue SO5126-9K
1
Protective cover for 600mm wide IMS experiment trolleys complete with experiments
Protective cover for 600mm wide IMS experiment trolleys complete with experiments ST8010-8M
Media:
1
Interactive Lab Assistant: IPA 2 Mixing station
Interactive Lab Assistant: IPA 2 Mixing station SO2805-4K
1
QuickChart, IPA 2 Mixing
QuickChart, IPA 2 Mixing SO6200-2F
S7-1500 PLC control system with accessories:
1
SIMATIC S7-1516-3 PN/DP 32 DE, 32 DA, 8 AE, 4 AA, 24V / 6 A power supply
SIMATIC S7-1516-3 PN/DP 32 DE, 32 DA, 8 AE, 4 AA, 24V / 6 A power supply CO3713-8R
1
Touch panel TP700 Comfort Trainer Package
Touch panel TP700 Comfort Trainer Package CO3713-4P
Media:
1
QuickChart Siemens SPS S7-1500 Board
QuickChart Siemens SPS S7-1500 Board SO6200-5K
1
QuickChart Touch Panel TP700
QuickChart Touch Panel TP700 SO6200-5H
Additionally required:
1
Compressor, low-noise
Compressor, low-noise SE2902-9L
1
Tubing and accessory set for mechatronics systems
Tubing and accessory set for mechatronics systems LM9670

In order to avoid condensation in areas of high humidity, the membrane dryer with water trap should be...   more

1
IDG3 membrane dryer with rapid coupling and filter AF20 with water trap
IDG3 membrane dryer with rapid coupling and filter AF20 with water trap LM9671
IMS/IPA Tester and Fault Simulator
1
IMS/IPA test and fault simulator
IMS/IPA test and fault simulator CO3713-7V
2
Serial interface cable 9/9 pole
Serial interface cable 9/9 pole LM9040
2
25-pin serial interface cable, Sub-D plug/socket
25-pin serial interface cable, Sub-D plug/socket LM9061
1
QuickChart IMS test and fault simulator
QuickChart IMS test and fault simulator SO6200-1Z